2000 Mitsubishi montero TSB

Mitsubishi! > Cars > Technical Service Bulletins (TSB) > USA > Models > montero > 2000



Sorted by Technical Servive Bulletin dates descending


2000 Mitsubishi MONTERO 00 - Sunroof > VISIBILITY : SUN ROOF ASSEMBLY [Part 134000 ]
TSB No: TSB0142A009 NHTSA ID: 625545 , July 01, 2001 : Replacement:
Summary: some vehicles may exhibit excessive wind noise and / or rattling at the sunroof while driving with the sunroof open. *tt


2000 Mitsubishi MONTERO 00 - Ignition > ELECTRICAL SYSTEM : IGNITION [Part 116000 ]
TSB No: TSB0116001 NHTSA ID: 18214 , February 01, 2001 : Replacement:
Summary: service manual revision on ignition cable removal. *jb


2000 Mitsubishi MONTERO 00 - Equipment > EQUIPMENT [Part 350000 ]
TSB No: 0013005 NHTSA ID: 13992 , August 01, 2000 : Replacement:
Summary: this bulletin contains obd-ii drive cycle procedures and warranty claim information for obd-ii drive cycle on affected vehicles. *tt


2000 Mitsubishi MONTERO 00 - Gas Fuel System > FUEL SYSTEM, GASOLINE [Part 070000 ]
TSB No: TSB0013003 NHTSA ID: 12489 , April 01, 2000 : Replacement:
Summary: information containing recommended fuels for certain vehicles. *tt


2000 Mitsubishi MONTERO 00 - Other > OTHER [Part 980000 ]
TSB No: 9954003R NHTSA ID: 6088713 , November 01, 1999 : Replacement: 99-54-003
Summary: experiencing a high frequency noise from the audio speaker. *tt


2000 Mitsubishi MONTERO 00 - Electrical System > ELECTRICAL SYSTEM [Part 110000 ]
TSB No: 9954009 NHTSA ID: 6088737 , October 01, 1999 : Replacement:
Summary: conditions with infinity audi volume fluctuation. *tt


2000 Mitsubishi MONTERO 00 - Automatic Transmission > POWER TRAIN : AUTOMATIC TRANSMISSION [Part 103000 ]
TSB No: 9923010 NHTSA ID: 6088731 , October 01, 1999 : Replacement:
Summary: this bulletin contains recommended automatic transmission / transaxle maintenance information. *tt


2000 Mitsubishi MONTERO SPORT 00 - Engine > ENGINE AND ENGINE COOLING : ENGINE [Part 061000 ]
TSB No: 0413002 NHTSA ID: , July 01, 2004 : Replacement: 0413002R
Summary: powertrain control module (pcm) reprogramming for engine hesitation / diagnostic trouble code (dtc) p0154. *tt


2000 Mitsubishi MONTERO SPORT 00 - Torque Convertor > POWER TRAIN : AUTOMATIC TRANSMISSION : TORQUE CONVERTER [Part 103700 ]
TSB No: 0323006 NHTSA ID: , October 01, 2003 : Replacement: 0123010
Summary: torque converter shudder, surge, and/or vibration (possibly intermittent) when driving 35-50 mph at steady throttle. *tt


2000 Mitsubishi MONTERO SPORT 00 - Automatic Transmission > POWER TRAIN : AUTOMATIC TRANSMISSION [Part 103000 ]
TSB No: 0323005 NHTSA ID: , September 01, 2003 : Replacement:
Summary: shift flare during the 2nd-to-3rd gear upshift may be due to learned data in the powertrain control module (pcm). *tt


2000 Mitsubishi MONTERO SPORT 00 - Engine exhaust > ENGINE AND ENGINE COOLING : EXHAUST SYSTEM [Part 063000 ]
TSB No: 94 NHTSA ID: , June 01, 2003 : Replacement:
Summary: oxygen sensor detection. *tt


2000 Mitsubishi MONTERO SPORT 00 - Air conditioner > EQUIPMENT : ELECTRICAL : AIR CONDITIONER [Part 353600 ]
TSB No: 0355004 NHTSA ID: , March 01, 2003 : Replacement:
Summary: air conditioner refrigerant quantity - service manual revision. *tt


2000 Mitsubishi MONTERO SPORT 00 - Body > STRUCTURE [Part 160000 ]
TSB No: 0323002 NHTSA ID: , January 01, 2003 : Replacement:
Summary: speedometer driven gear worn. *tt


2000 Mitsubishi MONTERO SPORT 00 - Air conditioner > EQUIPMENT : ELECTRICAL : AIR CONDITIONER [Part 353600 ]
TSB No: 0355001 NHTSA ID: , January 01, 2003 : Replacement: 0155006
Summary: a pulsating or rattle noise heard when the air conditioner is on. *tt


2000 Mitsubishi MONTERO SPORT 00 - Engine > ENGINE AND ENGINE COOLING : ENGINE [Part 061000 ]
TSB No: 0213018R NHTSA ID: , November 01, 2002 : Replacement: 0213018
Summary: powertrain control module (pcm) reprogramming for engine stalling / engine hesitation / diagnostic trouble code (dtc) p0154. *tt


2000 Mitsubishi MONTERO SPORT 00 - Engine exhaust > ENGINE AND ENGINE COOLING : EXHAUST SYSTEM [Part 063000 ]
TSB No: 0213019 NHTSA ID: , October 01, 2002 : Replacement:
Summary: incorrect powertrain control module (pcm) software parameters may cause oxygen sensor failure (diagnostic trouble code p0154). *tt


2000 Mitsubishi MONTERO SPORT 00 - Engine > ENGINE AND ENGINE COOLING : ENGINE [Part 061000 ]
TSB No: 0213018 NHTSA ID: , September 01, 2002 : Replacement:
Summary: powertrain control module (pcm) reprogramming for engine stalling / engine hesitation / diagnostic trouble code (dtc) p0154. *tt


2000 Mitsubishi MONTERO SPORT 00 - Other > OTHER [Part 980000 ]
TSB No: 85 NHTSA ID: 636825 , August 01, 2002 : Replacement:
Summary: on some vehicles, customers may find that when programming the rke answerback function the desired function change may not take place. *tt


2000 Mitsubishi MONTERO SPORT 00 - Gas Fuel System > FUEL SYSTEM, GASOLINE [Part 070000 ]
TSB No: 85 NHTSA ID: 636851 , August 01, 2002 : Replacement:
Summary: service review regarding tsb-02-13-014 - fuel tank differential pressure sensor - service manual revision. *tt


2000 Mitsubishi MONTERO SPORT 00 - Gas Tank Assembly > FUEL SYSTEM, GASOLINE : STORAGE : TANK ASSEMBLY [Part 071100 ]
TSB No: TSB0213014 NHTSA ID: 635092 , July 01, 2002 : Replacement: 0213014
Summary: subject regarding fuel tank differentialpressure sensor - service manual revision. *tt


2000 Mitsubishi MONTERO SPORT 00 - Gas Fuel System > FUEL SYSTEM, GASOLINE [Part 070000 ]
TSB No: 8113 NHTSA ID: 631467 , April 01, 2002 : Replacement:
Summary: subject regarding diagnostic trouble codes p0171 and p0174 for v6 models. *lc


2000 Mitsubishi MONTERO SPORT 00 - Ignition Module > ELECTRICAL SYSTEM : IGNITION : MODULE [Part 116200 ]
TSB No: 80 NHTSA ID: 637074 , March 01, 2002 : Replacement:
Summary: information on a diagnostic trouble code p0174 set *tt


2000 Mitsubishi MONTERO SPORT 00 - Horn > COMMUNICATIONS : HORN ASSEMBLY [Part 341000 ]
TSB No: 7954 NHTSA ID: 629937 , February 01, 2002 : Replacement:
Summary: customers may report that after pushing the horn button when the accessory socket is in use,the horn continues to blow when the button is released. *tt


2000 Mitsubishi MONTERO SPORT 00 - Other > OTHER [Part 980000 ]
TSB No: 0137A003 NHTSA ID: 631890 , December 01, 2001 : Replacement: 0137A003
Summary: subject regarding ball joint dust cover grease application, service manual revision. *slc


2000 Mitsubishi MONTERO SPORT 00 - Suspension > SUSPENSION [Part 020000 ]
TSB No: 0142A014 NHTSA ID: 627138 , December 01, 2001 : Replacement: 0042A003
Summary: some vehicles may experience vehicle body vibration.*jb


2000 Mitsubishi MONTERO SPORT 00 - Suspension > SUSPENSION [Part 020000 ]
TSB No: 0134002 NHTSA ID: 627134 , December 01, 2001 : Replacement:
Summary: information on shudder at acceleration, suspension bottoming out. *jb


2000 Mitsubishi MONTERO SPORT 00 - Driveshaft > POWER TRAIN : DRIVELINE : DRIVESHAFT [Part 105300 ]
TSB No: 0125001 NHTSA ID: 627082 , November 01, 2001 : Replacement:
Summary: subject regarding incorrect propeller shaft installation.*jb


2000 Mitsubishi MONTERO SPORT 00 - Transmission TCM PCM > POWER TRAIN : AUTOMATIC TRANSMISSION : CONTROL MODULE (TCM, PCM) [Part 103100 ]
TSB No: 0123007REV NHTSA ID: 627178 , November 01, 2001 : Replacement: 0123007
Summary: subject regarding powertrain control module reprogramming for 2-3 shift flare. *jb


2000 Mitsubishi MONTERO SPORT 00 - Driveshaft > POWER TRAIN : DRIVELINE : DRIVESHAFT [Part 105300 ]
TSB No: 011001 NHTSA ID: 627231 , October 01, 2001 : Replacement:
Summary: information regarding propeller shaft. *jb


2000 Mitsubishi MONTERO SPORT 00 - Transmission TCM PCM > POWER TRAIN : AUTOMATIC TRANSMISSION : CONTROL MODULE (TCM, PCM) [Part 103100 ]
TSB No: 011001 NHTSA ID: 627229 , October 01, 2001 : Replacement:
Summary: information on 2-3 shift flare, reprogramming the powertrain control module. *jb


2000 Mitsubishi MONTERO SPORT 00 - Body > STRUCTURE : BODY [Part 162000 ]
TSB No: 73 NHTSA ID: 625555 , August 01, 2001 : Replacement:
Summary: information on body vibration. *tt


2000 Mitsubishi MONTERO SPORT 00 - Hatchback > STRUCTURE : BODY : HATCHBACK/LIFTGATE [Part 162600 ]
TSB No: TSB0142A010 NHTSA ID: 625546 , August 01, 2001 : Replacement:
Summary: this bulletin contains instructions for eliminating a popping noise from the rear hatch area of the vehicle. *tt


2000 Mitsubishi MONTERO SPORT 00 - Driveshaft > POWER TRAIN : DRIVELINE : DRIVESHAFT [Part 105300 ]
TSB No: 73 NHTSA ID: 625553 , August 01, 2001 : Replacement:
Summary: subject regarding improvements to the prop shaft center bearing. *tt


2000 Mitsubishi MONTERO SPORT 00 - Driveshaft > POWER TRAIN : DRIVELINE : DRIVESHAFT [Part 105300 ]
TSB No: 25 NHTSA ID: 622482 , July 01, 2001 : Replacement:
Summary: subject regarding propeller shaft center bearing improvement. *tt


2000 Mitsubishi MONTERO SPORT 00 - Speed Control > VEHICLE SPEED CONTROL [Part 180000 ]
TSB No: TSB0117003 NHTSA ID: 622427 , July 01, 2001 : Replacement:
Summary: this bulletin provides corrected instructions for troubleshooting cruise control system trouble code dtc 12, vehicle speed sensor system which was incorrect in the service manuals. *tt


2000 Mitsubishi MONTERO SPORT 00 - Automatic Transmission > POWER TRAIN : AUTOMATIC TRANSMISSION [Part 103000 ]
TSB No: 23 NHTSA ID: 622480 , July 01, 2001 : Replacement:
Summary: fuel cut activation in 2wd. *tt


2000 Mitsubishi MONTERO SPORT 00 - Suspension > SUSPENSION [Part 020000 ]
TSB No: 42 NHTSA ID: 622486 , July 01, 2001 : Replacement:
Summary: brief information on body vibration. *tt


2000 Mitsubishi MONTERO SPORT 00 - Horn > COMMUNICATIONS : HORN ASSEMBLY [Part 341000 ]
TSB No: 54 NHTSA ID: 622466 , May 01, 2001 : Replacement:
Summary: brief information for diagnosing horn that operates by itself. *tt


2000 Mitsubishi MONTERO SPORT 00 - Air conditioner > EQUIPMENT : ELECTRICAL : AIR CONDITIONER [Part 353600 ]
TSB No: 55 NHTSA ID: 622469 , May 01, 2001 : Replacement:
Summary: brief information regarding a/c rattle /buzz. *tt


2000 Mitsubishi MONTERO SPORT 00 - Driveshaft > POWER TRAIN : DRIVELINE : DRIVESHAFT [Part 105300 ]
TSB No: 25 NHTSA ID: 622440 , May 01, 2001 : Replacement:
Summary: subject regarding propeller shaft shuuder on acceleration. *tt


2000 Mitsubishi MONTERO SPORT 00 - Rear Suspension > SUSPENSION : REAR [Part 022000 ]
TSB No: 33A NHTSA ID: 622444 , May 01, 2001 : Replacement:
Summary: subject regarding rear suspension helper kit for rear coil spring suspension equipped vehicles. *tt


2000 Mitsubishi MONTERO SPORT 00 - Horn > COMMUNICATIONS : HORN ASSEMBLY [Part 341000 ]
TSB No: 54 NHTSA ID: 622463 , May 01, 2001 : Replacement:
Summary: brief information on diagnosing a horn that operates continuously (won't go off). *tt


2000 Mitsubishi MONTERO SPORT 00 - Transmission TCM PCM > POWER TRAIN : AUTOMATIC TRANSMISSION : CONTROL MODULE (TCM, PCM) [Part 103100 ]
TSB No: TSB0100008 NHTSA ID: 19817 , March 01, 2001 : Replacement:
Summary: mitsubishi motors dealers who have the medic system can reprogram the red rom pack used for reflashing various vehicle's pcms. *tt


2000 Mitsubishi MONTERO SPORT 00 - Transmission TCM PCM > POWER TRAIN : AUTOMATIC TRANSMISSION : CONTROL MODULE (TCM, PCM) [Part 103100 ]
TSB No: TSB0117001 NHTSA ID: 19821 , March 01, 2001 : Replacement:
Summary: some affected vehicles may experience a single shift flare when upshifting from 2nd to 3rd gear after warm engine restart. *tt


2000 Mitsubishi MONTERO SPORT 00 - Torque Convertor > POWER TRAIN : AUTOMATIC TRANSMISSION : TORQUE CONVERTER [Part 103700 ]
TSB No: TSB0123003 NHTSA ID: 18181 , February 02, 2001 : Replacement:
Summary: this bulletin contains information concerning the application of sealant to the torque converter housing during reassembly. *jb


2000 Mitsubishi MONTERO SPORT 00 - Automatic Transmission > POWER TRAIN : AUTOMATIC TRANSMISSION [Part 103000 ]
TSB No: TSB0123005 NHTSA ID: 18184 , February 01, 2001 : Replacement:
Summary: information on procedures for removing and installing the automatic transmission oil pan using oil pan remover special tool md998727-01. *jb


2000 Mitsubishi MONTERO SPORT 00 - Transmission Column Shift > POWER TRAIN : AUTOMATIC TRANSMISSION : LEVER AND LINKAGE : COLUMN SHIFT [Part 103400 ]
TSB No: TSB0123002 NHTSA ID: 18216 , February 01, 2001 : Replacement: TSB0023004
Summary: some 4-wheel drive models may exhibit a transfer lever stuck in 4h. *tt


2000 Mitsubishi MONTERO SPORT 00 - Other > OTHER [Part 980000 ]
TSB No: 67 NHTSA ID: 18222 , February 01, 2001 : Replacement:
Summary: subject pertaining to fuel diagnostic trouble code p0125. *jb


2000 Mitsubishi MONTERO SPORT 00 - Automatic Transmission > POWER TRAIN : AUTOMATIC TRANSMISSION [Part 103000 ]
TSB No: 67 NHTSA ID: 18227 , February 01, 2001 : Replacement:
Summary: information on diagnosing transfer lever stuck in 4h and torque converter vibration / shudder / surge condition. *tt


2000 Mitsubishi MONTERO SPORT 00 - Transmission Column Shift > POWER TRAIN : AUTOMATIC TRANSMISSION : LEVER AND LINKAGE : COLUMN SHIFT [Part 103400 ]
TSB No: 66 NHTSA ID: 16776 , December 01, 2000 : Replacement:
Summary: information regarding transfer case shifter rattle. *tt


2000 Mitsubishi MONTERO SPORT 00 - Other > OTHER [Part 980000 ]
TSB No: TSB0042A009 NHTSA ID: 15965 , November 01, 2000 : Replacement: TSB0042A009
Summary: this bulletin contains corrected and revised descriptions, references, and troubleshooting information relating to the factory-installed keyless entry system. *tt


2000 Mitsubishi MONTERO SPORT 00 - Automatic Transmission > POWER TRAIN : AUTOMATIC TRANSMISSION [Part 103000 ]
TSB No: TSB0023007 NHTSA ID: 15969 , November 01, 2000 : Replacement:
Summary: this bulletin contains information concerning a new, improved automatic transmission fluid (atf) level gauge which is now available for certain model year vehicles. *tt


2000 Mitsubishi MONTERO SPORT 00 - Automatic Transmission > POWER TRAIN : AUTOMATIC TRANSMISSION [Part 103000 ]
TSB No: TSB0023008 NHTSA ID: 15968 , November 01, 2000 : Replacement:
Summary: some vehicles may exhibit an automatic transmission overheat temperature indicator when driven under heavy load conditions such as high speed operation or trailer towing or when the transmission is over-filled. *tt


2000 Mitsubishi MONTERO SPORT 00 - Suspension > SUSPENSION [Part 020000 ]
TSB No: TSB0033A002 NHTSA ID: 18217 , October 01, 2000 : Replacement:
Summary: service manual revision on toe-in specification. *jb


2000 Mitsubishi MONTERO SPORT 00 - Sunroof > VISIBILITY : SUN ROOF ASSEMBLY [Part 134000 ]
TSB No: TSB0042A007 NHTSA ID: 14964 , September 01, 2000 : Replacement: TSB0042A007
Summary: this bulletin contains revised details for sunroof water test and fit adjustment procedures - service manual revision. *tt


2000 Mitsubishi MONTERO SPORT 00 - Windshield > VISIBILITY : WINDSHIELD [Part 131000 ]
TSB No: TSB0042A005 NHTSA ID: 14002 , August 01, 2000 : Replacement:
Summary: concern with windshield wind (buzz, hum or whistle) noise, especially in the a-pillar area or across the top of the windshield occuring when driving at highway speeds. the noise may be intermittent, and typically is more evident at ambie


2000 Mitsubishi MONTERO SPORT 00 - Equipment > EQUIPMENT [Part 350000 ]
TSB No: 0013005 NHTSA ID: 13992 , August 01, 2000 : Replacement:
Summary: this bulletin contains obd-ii drive cycle procedures and warranty claim information for obd-ii drive cycle on affected vehicles. *tt


2000 Mitsubishi MONTERO SPORT 00 - Transfer Case > POWER TRAIN : TRANSFER CASE (4-WHEEL DRIVE) [Part 104000 ]
TSB No: TSB0023004 NHTSA ID: 13997 , May 01, 2000 : Replacement:
Summary: a condition may exist on 4-wheel-drive models, if the driver tries to shift the transfer lever from 4l to 4h while the vehicle is moving, the lever may become stuck in 4h. shifting from 4l to 4h should only be done with the vehicle s


2000 Mitsubishi MONTERO SPORT 00 - Air conditioner > EQUIPMENT : ELECTRICAL : AIR CONDITIONER [Part 353600 ]
TSB No: TSB0055001R NHTSA ID: 14005 , May 01, 2000 : Replacement: TSB0055001
Summary: concerns with road debris (such as asphalt or small rocks) pushed into the a/c condenser fan during operation, resulting in insufficient opening in the fan shroud for the debris to escape. *tt


2000 Mitsubishi MONTERO SPORT 00 - Air conditioner > EQUIPMENT : ELECTRICAL : AIR CONDITIONER [Part 353600 ]
TSB No: TSB0055001 NHTSA ID: 12484 , April 01, 2000 : Replacement:
Summary: information concerning air conditioner condenser damage. *tt


2000 Mitsubishi MONTERO SPORT 00 - Other > OTHER [Part 980000 ]
TSB No: TSB0042A004 NHTSA ID: 12482 , April 01, 2000 : Replacement:
Summary: this bulletin helps clarify the proper remote keyless entry (rke) answerback deactivation / reactivation function procedure by using only the vehicle's rke transmitter. *tt


2000 Mitsubishi MONTERO SPORT 00 - Gas Fuel System > FUEL SYSTEM, GASOLINE [Part 070000 ]
TSB No: TSB0013003 NHTSA ID: 12489 , April 01, 2000 : Replacement:
Summary: information containing recommended fuels for certain vehicles. *tt


2000 Mitsubishi MONTERO SPORT 00 - Body > STRUCTURE [Part 160000 ]
TSB No: TSB9942A010 NHTSA ID: 15975 , November 01, 1999 : Replacement:
Summary: this bulletin contains information about a new stronger rear liftgate gas spring. this new spring is being introduced to eliminate a condition where the gas springs may not allow the rear liftgate to open satisfactorily. *tt


2000 Mitsubishi MONTERO SPORT 00 - Ignition Module > ELECTRICAL SYSTEM : IGNITION : MODULE [Part 116200 ]
TSB No: 9954008 NHTSA ID: 6088735 , October 01, 1999 : Replacement:
Summary: information regarding a numer of immobilizer ecus not having override codes. *tt


2000 Mitsubishi MONTERO SPORT 00 - Anti-theft ignition > ELECTRICAL SYSTEM : IGNITION : ANTI-THEFT CONTROLLER [Part 116300 ]
TSB No: 9954010 NHTSA ID: 6088721 , October 01, 1999 : Replacement:
Summary: information concerning a no-start condition caused by immobilizer ignition key interference. *tt


2000 Mitsubishi MONTERO SPORT 00 - Automatic Transmission > POWER TRAIN : AUTOMATIC TRANSMISSION [Part 103000 ]
TSB No: 9923010 NHTSA ID: 6088731 , October 01, 1999 : Replacement:
Summary: this bulletin contains recommended automatic transmission / transaxle maintenance information. *tt


2000 Mitsubishi MONTERO SPORT 00 - Radio CD Player > EQUIPMENT : ELECTRICAL : RADIO/TAPE DECK/CD ETC. [Part 353400 ]
TSB No: 9954007 NHTSA ID: 6088716 , September 01, 1999 : Replacement:
Summary: this bulletin clarifies the installation instructions for the 6-disc in-dash cd changer. *tt


2000 Mitsubishi MONTERO SPORT 00 - Engine exhaust > ENGINE AND ENGINE COOLING : EXHAUST SYSTEM [Part 063000 ]
TSB No: 48 NHTSA ID: 6600 , June 01, 1999 : Replacement:
Summary: information evap diagnostic trouble code (dtc) troubleshooting. *tt


2000 Mitsubishi MONTERO SPORT 00 - Anti-theft ignition > ELECTRICAL SYSTEM : IGNITION : ANTI-THEFT CONTROLLER [Part 116300 ]
TSB No: TSB9900003R NHTSA ID: 8409 , June 01, 1999 : Replacement: TSB9900003
Summary: this bulletin contains additional pdi procedures and service information concerning the anti-theft engine immobilizer system with security keys. *tt


2000 Mitsubishi MONTERO SPORT 00 - Anti-theft ignition > ELECTRICAL SYSTEM : IGNITION : ANTI-THEFT CONTROLLER [Part 116300 ]
TSB No: TSB9900003 NHTSA ID: 8399 , June 01, 1999 : Replacement:
Summary: information on pdi procedures concerning the new immobilizer system feature on certain 2000 model year mitsubishi vehicles. * mjs



Source TSB Technical Service Bulletins of Mitsubishi from National Highway Traffic and Safety Adminstration (NHTSA)

Last Update: August 28, 2004